Play Video

Gel-like fluid fights wildfires before they start

(Credit: Getty Images)

An environmentally benign gel-like fluid that helps common fire retardants last longer on vegetation could greatly reduce the incidence and severity of wildfires, researchers say.

The materials retain their ability to prevent fires throughout the peak fire season, even after weathering that would sweep away conventional fire retardants. By stopping fires from starting, these kinds of treatments can be more effective and less expensive than current firefighting methods.

“This has the potential to make wildland firefighting much more proactive, rather than reactive,” says Eric Appel, an assistant professor of materials science and engineering in the School of Engineering at Stanford University and senior author of the paper in PNAS.

“What we do now is monitor wildfire-prone areas and wait with bated breath for fires to start, then rush to put them out.”

The untreated patch on the left is heavily burned, whereas the treated patch on the right is largely untouched by fire
Under the supervision of CalFire, the researchers performed test burns on a grassy roadside area near San Luis Obispo, California to gauge the effect of a fire-retarding hydrogel. The images above show untreated (left) and treated (right) plots shortly after fire ignition. (Credit: Eric Appel/Stanford)

A century of fire suppression plus hotter, drier weather has intensified the destructive power of wildfires and lengthened the season of threat. While the 2019 season has been relatively calm in the West so far, the past two years have brought four of the 20 largest and eight of the 20 most destructive wildfires in California’s history. Across the country, federal firefighting costs in 2018 came to more than $3 billion—the highest total ever.

A better way to fight wildfires

Wildfires are a critical part of some ecosystems, but humans have caused the vast majority in the US. Many of them originate in the same hotspots, such as roadsides, campgrounds, and remote electrical lines, time after time. Treating these areas prophylactically could provide a highly targeted approach to wildfire prevention, but, until now, long-lasting and environmentally benign materials have not been available.

“You can put 20,000 gallons of this on an area for prevention, or 1 million gallons of the traditional formulation after a fire starts.”

Aside from clearing and burning potential fuels, wildfire management generally revolves around fire suppressants and retardants, with many suppressants used as short-term retardants.

To fight active fires, crews use suppressants, such as gels that carry water and the kind of superabsorbent polymers found in diapers. Officials frequently use these gels as short-term retardants on buildings in the path of encroaching fires, but they lose effectiveness once the water entrapped in them evaporates—something that often occurs in less than an hour during normal wildland fire conditions.

The most widely deployed commercial wildland fire retardant formulations use ammonium phosphate or its derivatives as the active fire-retarding component. However, these formulations only hold retardants on vegetation for short periods of time, so firefighters can’t use them preventively.

By contrast, the new technology—a cellulose-based gel-like fluid—stays on target vegetation through wind, rain, and other environmental exposure.

“You can put 20,000 gallons of this on an area for prevention, or 1 million gallons of the traditional formulation after a fire starts,” says lead author Anthony Yu, a PhD student in materials science and engineering.

Gel even works when wet

The researchers worked with the California Department of Forestry and Fire Protection (CalFire) to test the retardant materials on grass and chamise—two vegetation types where fire frequently starts and discovered the treatment provides complete fire protection even after half an inch of rainfall.

Under the same conditions, a typical commercial retardant formulation provides little or no fire protection. The researchers are now working with the California Department of Transportation and CalFire to test the material on high-risk roadside areas that are the origin of dozens of wildfires every year.

“We don’t have a tool that’s comparable to this,” says Alan Peters, a CalFire division chief in San Luis Obispo who monitored some of the test burns. “It has the potential to definitely reduce the number of fires.”

The treatment contains only nontoxic starting materials widely used in food, drug, cosmetic, and agricultural products. The unique properties of the gel-like retardant fluids allows application using standard agricultural spraying equipment or from aircraft. While it washes away slowly, providing the ability to protect treated areas against fire for months, the materials eventually degrade.

“We hope these new materials can open the door to identifying and treating high-risk areas to protect people’s lives and livelihoods,” Appel says.

Source: Stanford University